Product ID:CERAMIC TITLE
MSDS Date:02/04/1991
FSC:8030
NIIN:00N083543
MSDS Number: CGQXX

BOSTIK INC

BOSTON STREET
MIDDLETON, MA 01949
US

Emergency Phone: 800-227-0332

Info Phone: 508-777-0100

Cage: EO689

BOSTIK INC.

MIDDLETON, MA 01949 US

Telephone: 978-777-0100/800-227-0332

Cage: 5W425

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 0.5-5%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9495

SILICATE, PORTLAND CEMENT; (PORTLAND CEMENT)

CAS: 65997-15-1

RTECS: VV8770000

Fraction By Weight: 30-40%

OSHA PEL 50 MPPCF; Z-3

ACGIH TLV: 10 MG/M3 TDUST; 9495

SILICA GEL; (SILICON DIOXIDE SAND)

CAS: 112945-52-5

RTECS: VV7310000

Fraction By Weight: 60-70%

OSHA PEL 6 MG/M3

ACGIH TLV: 10 MG/M3

FORMIC ACID, CALCIUM SALT; (CALCIUM FORMATE)

CAS: 544-17-2

RTECS: LQ5600000

OSHA PEL N/K

ACGIH TLV: N/K

SILICA, CRYSTALLINE - CRISTOBALITE; (CRISTOBALITE)

CAS: 14464-46-1

RTECS: VV7325000

OSHA PEL N/K

ACGIH TLV: 0.05 MG/M3 RDUST

PROD WOULD NOT BE CLASSIFIED AS HAZ WASTE

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:THE INFO SHOWN BELOW REFERS GENERALLY
TO A COMPONENT OF THE PRODUCT BUT AS REQUIRED BY OSHA 1910.1200 THE
HAZARDS OF ANY INGREDIENT MUST BE EXTENDED TO THE PRODUCT AS A
WHOLE UNLESS TESTING TO THE PRO DUCT HAS BEEN PERFORMED. THE U.S.
ANSI Z129.1-1982 WAS USED AS A GUIDE WHEN THIS MSDS WAS WRITTEN.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-CRISTOBALITE: IARC
MONO, VOL 68, 1997:GRP 1. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC
TO BE CARCIN.
Effects of Overexposure:HLTH HAZ:INGEST & ABSORPTION: NO HAZ KNOWN AT
THIS TIME. INHAL: HAZ IF INHALED. INGREDIENT HAS AN LC50 OF
1500-2500 PPM OR 500-2500 MG/M3/IS REGULATED BY A TLV/PEL.
CONTACT:INGREDIENT CAUSES EYE &/SKI N IRRIT. CORROSION:NO HAZ KNOWN
AT THISTIME. SYMPS OF OVEREXP:IRRIT, MUC MEMB IRRIT, COUGHING, POSS
CHEM BURN. (SUPDAT)
Medical Cond Aggravated by Exposure:DERMATITIS.

First Aid:INGEST: CALL MD IMMEDIATELY . SKIN: FLUSH W/COPIOUS AMOUNTS
OF WATER. CALL MD . INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING
GIVE ARTIFICIAL RESPIRATION, PREFERABLY MOUTH TO MOUTH. IF BREA
THING IS DIFFICULT GIVE OXYGEN. CALL A PHYSICIAN. EYES: IN CASE OF
CONTACT, IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST
15 MINUTES. CALL A PHYSICIAN.

Flash Point:NONE
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN TO BOSTIK.

Spill Release Procedures:SWEEP UP MATERIAL USING SWEEPING COMPOUND AND
PACKAGE THE SOLID PRODUCT IN STEEL DRUMS WHICH ARE IN GOOD
CONDITION. THOROUGHLY CLEAN AREA WHERE SPILL OCCURRED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL LOCATION (60-80
DEGREES F) AWAY FROM SUNLIGHT AND ANY SOURCE OF HEAT. KEEP
CONTAINER TIGHTLY CLOSED WHEN NOT BEING USED.
Other Precautions:USE WITH ADEQUATE VENTILATION. AVOID PROLONGED OR
REPEATED BREATHING OF VAPORS. AVOID SKIN CONTACT.

Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST IS PREFERRED TO KEEP VAPOR OR DUST BELOW THE
TLV VALUE. MECHANICAL AREAWIDE VENTILATION IS ACCEPTABLE.
Protective Gloves:CLOTH GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV:2.88 24.00 POUNDS PER GALLON. HAZ DECOMP PROD:CARBON DIOXIDE,
CARBON MONOXIDE, H*2O VAP, OXIDES OF NITROGEN/A WIDE VARIETY OF
INNOCUOUS/TOX FUMES. EFTS OF OVEREXP:CHRONIC EFTS:LONG TERM OVER
EXP TO HAZ MATLS IN THIS PROD HAVE BEENASSOCD W/DERM, CUMULATIVE
LUNG DMG. TARGET ORGANS:EYES, RESP SYSTEM, SKIN, LUNG.

Spec Gravity:SUPDAT
Solubility in Water:0.1%
Appearance and Odor:A POWDER WITH NO ODOR.
Percent Volatiles by Volume:0.0

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:UNKNOWN DUE TO COMPLEX NATURE OF THIS
MATL. FUMES FROM COMPLETE/INCOMPLETE COMBUST OF THIS MATL MAY
INCLUDE (SUPDAT)

Waste Disposal Methods:DISPOSE OF I/A/W/FED, STATE, & LOCAL RULES. BE
AWARE THAT STATE & LOCAL REQUIREMENTS MAY DIFFER WIDELY DEPENDING
ON LOCATION & MAY IN MANY CASES BE DIFF FROM FED RULES. WHEN
INTENDING TO DISPOSE OF TH IS MATL, THE USER IS ADVISED THAT THIS
(ING 6)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.